Product ID:TURBINE FUEL, AVIATION JP-5
MSDS Date:11/18/1989
FSC:9130
NIIN:00-273-2379
MSDS Number: BKMDX

CHEVRON ENVIRONMENTAL HEALTH CENTER INC.

15299 SAN PABLO AVE.
RICHMOND, CA 94804-0054
US

Emergency Phone: 415-233-3737

Info Phone: 415-233-3737

Cage: 0AHD1

CHEVRON ENVIRONMENTAL HEALTH CENTER INC

4054 RICHMOND, CA 94804 US

Telephone: 800-582-3835

Cage: 0AHD1

DISTILLATE, WIDE BOILING RANGE; ALIPHATIC AND AROMATIC

Fraction By Weight: >75%

HEXANE (N-HEXANE)

CAS: 110-54-3

RTECS: MN9275000

Fraction By Weight: <25%

OSHA PEL 500 PPM

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

BENZENE (SARA III)

CAS: 71-43-2

RTECS: CY1400000

Fraction By Weight: <.1%

OSHA PEL 1PPM/5STEL;1910.1028

ACGIH TLV: 10 PPM; A2; 9192

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

ETHYL BENZENE (SARA III)

CAS: 100-41-4

RTECS: DA0700000

Fraction By Weight: 0.1%

OSHA PEL 100 PPM/125 STEL

ACGIH TLV: 100 PPM/125STEL 9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

XYLENES (O-,M-,P- ISOMERS) (SARA III)

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: <.3%

OSHA PEL 100 PPM/150 STEL

ACGIH TLV: 100 PPM/150STEL;9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: <.1%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:THIS PRODUCT IS NOT EXPECTED TO CAUSE
PROLONGED OR SIGNIFICANT EYE OR SKIN IRRITATION. PROLONGED
BREATHING OF VAPORS CAN CAUSE CENTRAL NERVOUS SYSTEMS EFFECTS. IF
INGESTED, IT IS PRACTICALLY NON-TOXIC , BUT BECAUSE OF ITS LOW
VISCOSITY, IT CAN DIRECTLY ENTER THE LUNGS & CAN CAUSE SEVERE
INJURY TO THE LUNGS OR DEATH.
Explanation of Carcinogenicity:NONE OF THE CHEMICALS IN THIS PRODUCT IS
LISTED BY IARC, NTP OR OSHA AS A CARCINOGEN.
Effects of Overexposure:INHALATION-HEADACHE, DIZZINESS, LOSS OF
APPETITE, WEAKNESS AND LOSS OF COORDINATION INGESTION-IF ASPIRATED
IT CAN CAUSE DEATH.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYE-FLUSH WITH WATER FOR 15 MINUTES. SKIN-REMOVE CONTAMINATED
CLOTHES. WASH WITH SOAP AND WATER. SEE A DOCTOR. INHALATION-REMOVE
TO FRESH AIR. SEE A DOCTOR IF SYMPTOMS OCCUR. INGESTION-DO NOT
INDUCE V OMITING. GIVE WATER OR MILK TO DRINK. GET MEDICAL
ATTENTION.

Flash Point Method:PMCC
Flash Point:140F,60C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:DO NOT ENTER ENCLOSED AREA WITHOUT PROTECTIVE
EQUIPMENT AND A SELF CONTAINED BREATHING APPARATUS TO PROTECT
AGAINST DECOMPOSITION PRODUCTS OR OXYGEN DEPLETION.
Unusual Fire/Explosion Hazard:LIQUID EVAPORATES & FORM VAPOR/FUMES
WHICH CAN IGNITE & BURN WITH EXPLOSIVE VIOLENCE. UNSEEN VAPORS CAN
SPREAD & IGNITE IN OTHER AREAS. HAZARD IS > ABOVE 85F.

Spill Release Procedures:ELIMINATE ALL OPEN FLAMES. STOP THE SOURCE OF
THE LEAK OR RELEASE. CLEAN UP SPILL AS SOON AS POSSIBLE, OBSERVING
PRECAUTIONS IN PROTECTIVE EQUIPMENT. CLEAN UP SMALL SPILL USING
APPROPIATE TECHNIQUES S UCH AS SORBENT MATERIALS OR PUMPING.

Handling and Storage Precautions:DO NOT USE OR STORE NEAR FLAME, SPARKS
OR HOT SURFACES. USE ONLY IN WELL VENTED AREA. KEEP CONTAINER
CLOSED. DO NOT WELD, HEAT OR DRILL CONTAINER.
Other Precautions:EMPTIED CONTAINER STILL CONTAINS HAZARDOUS OR
EXPLOSIVE VAPOR OR LIQUID. CAUTION! DO NOT USE PRESSURE TO EMPTY
DRUM OR EXPLOSION MAY RESULT. WARNING! NOT FOR USE AS PORTABLE
HEATER OR APPLIANCE FUEL. TOXIC FUMES MAY ACCUMULATE & CAUSE DEATH

Respiratory Protection:THIS MATERIAL MAY BE AN INHALATION HAZARD &,
UNLESS VENTILATION IS ADEQUATE, THE USE OF AN APPROVED RESPIRATOR
IS RECOMMENDED. REFER TO THE OSHA BENZENE STANDARD TO DETERMINE
WHAT TYPE OF RESPIRATOR I S REQUIRED BASED ON EXPOSURE LEVELS.
Ventilation:USE THIS MATERIAL ONLY IN WELL VENTILATED AREAS.
Protective Gloves:PROTECTIVE GLOVES IS RECOMMENDED.
Eye Protection:NO SPECIAL EYE WEAR IS USUALLY NECESSARY
Other Protective Equipment:SAFETY SHOWER AND EYE BATH. INDUSTRIAL TYPE
WORK CLOTHING IS REQUIRED TO AVOID PROLONGED OR REPEATED CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING OR DRINKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health

HCC:F4
Boiling Pt:B.P. Text:365F,185C
Vapor Pres:0.04
Spec Gravity:0.82
Solubility in Water:INSOLUBLE
Appearance and Odor:PALE YELLOW LIQUID.

Stability Indicator/Materials to Avoid:YES
MAY REACT WITH STRONG OXIDIZING AGENTS, SUCH AS CHLORATES, NITRATES,
PEROXIDES, ETC.
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION.
Hazardous Decomposition Products:NORMAL COMBUSTION FORMS CARBON DIOXIDE
AND WATER VAPOR; INCOMPLETE COMBUSTION CAN PRODUCE CARBON MONOXIDE.

Waste Disposal Methods:PLAVE CONTAMINATED MATERIALS IN DISPOSABLE
CONTAINERS AND DISPOSE OF IN A MANNER CONSISTENT WITH APPLICABLE
REGULATIONS. CONTACT LOCAL ENVIRONMENTAL OR HEALTH AUTHORITIES FOR
APPROVED DISPOSAL OF THIS MATERIAL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.